Managing Electrical Conductivity (EC) For Hydroponic Basil Production

Managing nutrient solutions is one of the most important responsibilities in hydroponic crop production. When managing the concentration of nutrients, we use electrical conductivity (EC) as a guide to maintaining and adjusting our nutrient levels, trying to provide adequate nutrients and minimize excessive fertilizer use. However, what EC is required for our crops? We wanted to better understand how nutrient solution EC affects basil growth and tissue nutrient concentrations under different daily light integrals (DLIs).

In an effort to provide research-based support for hydroponic basil producers, we have been conducting a suite of research studies focused on various aspects of production. We’ve already shared our results on the effects cultivars, hydroponic systems, and planting densities have on the growth and yield of basil.

Next month, we will be looking at how temperature influences basil growth and development. However, in this article we will present research on how the nutrient solution EC affects growth and tissue concentration of hydroponic basil.

Nutrient Solution ECs And Daily Light Integrals

First, we transplanted two-week-old sweet, holy, and lemon basil seedlings into nutrient-film technique (NFT) hydroponic systems with nutrient solution EC of 0.5, 1, 2, 3, or 4 mS∙cm−1.

The nutrient solution consisted of deionized water and 16N−1.8P−14.3K fertilizer (Jack’s Hydro FeEd; JR Peters), and the ECs were maintained at their target level daily by adding concentrated stock solution or clear water to raise or lower the EC, respectively. The nutrient solution pH was adjusted to 6 daily, aerated, and circulated through a heater/chiller unit to maintain a water temperature of 72°F.

Supplemental lighting was provided by HPS (high pressure sodium) lamps to increase the light intensity during the day for the plants grown under a high DLI, and provide a 16-hour day length for plants grown under both low and high DLIs. Aluminized shade cloth was also used to decrease daytime light intensity for plants grown under a low DLI. The low DLI greenhouse was maintained at a DLI of ~7 mol∙m−2∙d−1, while the high DLI greenhouse was maintained at ~15 mol∙m−2∙d−1. Three weeks after transplanting, we measured height, node and branch number, and fresh and dry mass of shoots.

Satisfactory Growth And Nutrition Observed

Basil had comparable growth (fresh and dry mass, branches, nodes) across nutrient solution ECs and there were no significant differences (Figure 1).

Figure 1. Ocimum basilicum electrical conductivity
Figure 1. Sweet basil grown with ECs ranging from 0.5 to 4 mS∙cm−1 under low (~7 mol∙m−2∙d−1) or high (~15 mol∙m−2∙d−1) daily light integrals (DLIs). This photo was taken three weeks after transplanting seedlings into hydroponic systems and treatments.

 

Although EC has no effect on basil growth, growth increased for all three basil species grown under ~15 mol∙m−2∙d−1 compared to those grown under 7 mol∙m−2∙d−1. There was no interaction between the EC and DLI on basil growth.

In addition to the growth and yield of basil, we also wanted to measure how tissue nutrient concentrations were affected by nutrient solution EC. When we looked at the nutrient concentrations, the results varied by nutrient. For example, for nitrogen, phosphorous, and sulfur, tissue concentration increased as nutrient solution EC increased from 0.5 to 4 mS∙cm−1 (Figure 2). Alternatively, calcium and magnesium tissue concentrations were lower with increasing EC.

Chart of nitrogen concentration of sweet basil grown with various ECs
Figure 2. Nitrogen (N) concentration of sweet basil grown with ECs ranging from 0.5 to 4 mS∙cm−1 under low (~7 mol∙m−2∙d−1) or high (~15 mol∙m−2∙d−1) daily light integrals (DLIs). Data was collected three weeks after transplanting seedlings into hydroponic systems and treatments.

What we found most interesting was that when the tissue nutrient concentrations are compared with recommended tissue concentrations for basil, the majority of values were within or above the recommended ranges, including those plants grown with the lowest EC (0.5 mS∙cm−1). For those few nutrients that were slightly below recommended values, we saw no visible signs of nutrient deficiencies and all plants, regardless of the EC, appeared healthy.

Managing Hydroponic Basil Nutrition

What are the implications of this research for managing nutrient solutions? First, the fact that most nutrients were within sufficient ranges and plants appeared healthy with no differences in yield across all of the ECs for all three species demonstrates that high-quality basil can be grown under a very wide range of ECs. This provides some opportunities and flexibility for hydroponic producers. A lower EC may help minimize fertilizer costs, whereas a higher EC may be useful to diminish the change in nutrient ratios in solution.

While not reported here, we did measure increased potassium concentrations in the nutrient solution from the beginning to the end of the production period. We attribute this increase in potassium to the potassium carbonate base we were using to increase solution pH.

Additionally, we suspect that the increased potassium concentrations may have antagonized uptake of calcium and/or magnesium. Always remember that additions to nutrient solutions such as acids or bases can add nutrients available for plants.

We were not surprised to see improved growth under the higher DLI. Previous research has reported increases in growth of up to ~500 µmol∙m−2∙d−1, so we were not surprised to see enhanced growth under the higher DLI. We were surprised to see that there was no effect of EC on basil growth. While we found that DLI affected growth, the lack of an interaction with EC to affect growth means that you do not need to change your EC as light intensity and the DLI change across seasons. While some producers lower their EC, we suspect this to be due to warmer temperatures and not higher light.

Take-Home Messages For Hydroponic Production

The bottom line is that basil grows well under a wide range of ECs. Most interestingly, basil yield, nutrient concentrations, and appearance were acceptable across ECs, even at low levels. Additionally, if there is an opportunity to increase the DLI or light intensity for basil production, basil responds very favorably to high light. Because the results may also vary across different locations, greenhouse environments, and cultural practices, as always, we encourage producers to conduct on-site trials to determine optimal nutrient-solution concentrations for the cultivars they are growing in their greenhouse environment.

Topics: ,

Leave a Reply to Janeen Wright Cancel reply

4 comments on “Managing Electrical Conductivity (EC) For Hydroponic Basil Production

  1. Figure 1 is incorrect. The text says that the foto shows plants and different EC’s but the foto shows plants under a temp gradient.

  2. Hello,

    I have met Chris Currey on a few occasions and listened to him speak, and am currently working on finding the ideal light levels for our sweet basil at an indoor hydroponic facility, so I was happy to come across this article!

    However, I believe there is a minor mistakethat needs correcting. You say, “Previous research has reported increases in growth of up to ~500 µmol∙m−2∙d−1.” However, I’m almost positive you mean ~500 µmol∙m−2∙s−1. (This is the difference between an instantaneous light measurement vs. daily light integral, for anyone interested.)

    I am sourcing this directly from the book “Light Management in Controlled Environments” by Roberto Lopez and Erik S. Runkle: “Research at Iowa State University reported that growth of sweet basil increased as light intensity increased up to ~500 µmol∙m−2∙s−1 and further increasing intensity caused no additional increase (Beaman et al., 2009).

    Thanks for all the great info!

More From Production...
lucas-greenhouses-plant-roots-growing-mix

January 19, 2018

8 Opportunities to Help You Prepare for the Spring Growing Season

Three New England universities are collaborating on a weekly webinar program covering topics such as pest management, making the most of growing media, and more.

Read More
Whitefly-Feeding-on-Poinsettias-feature

January 18, 2018

Mitigating Whiteflies in Ornamental Production

Gain better control over common greenhouse and nursery pests with these best practices.

Read More
Iron-Chlorosis-in-Hydrangea-feature

January 12, 2018

How pH and EC Monitoring Can Help You Manage Nutrition in the Greenhouse

In part two of this five-part series about the tools you need to keep track of your greenhouse environment, learn about the various methods for tracking pH and EC.

Read More
Latest Stories
lucas-greenhouses-plant-roots-growing-mix

January 19, 2018

8 Opportunities to Help You Prepare for the Spring Grow…

Three New England universities are collaborating on a weekly webinar program covering topics such as pest management, making the most of growing media, and more.

Read More
Whitefly-Feeding-on-Poinsettias-feature

January 18, 2018

Mitigating Whiteflies in Ornamental Production

Gain better control over common greenhouse and nursery pests with these best practices.

Read More
Iron-Chlorosis-in-Hydrangea-feature

January 12, 2018

How pH and EC Monitoring Can Help You Manage Nutrition …

In part two of this five-part series about the tools you need to keep track of your greenhouse environment, learn about the various methods for tracking pH and EC.

Read More
Leaf-Distortion-in-New-Guinea-Impatiens

January 11, 2018

Plan Ahead for Spring Season in the Greenhouse by Follo…

In a recent report on the Michigan State University Extension website, Floriculture Educator Jeremy Jubenville presents a short list of ideas that can help growers nip predictable problems in the bud, so they have more time to focus on any new situations that arise.

Read More
Dummen-Orange-Koppert-GreenGuard-Program

January 11, 2018

Dümmen Orange, Koppert Partner on Launch of New IPM Sys…

Dümmen Orange plans to incorporate Koppert Biological System’s beneficial insects into its pot chrysanthemum cuttings program, with the end goal being minimal use of chemicals further down the chain.

Read More
Irrigation-feature

January 8, 2018

How Clean Is Your Greenhouse Irrigation System?

The start of a new year is a good time to double check your irrigation system to make sure your crops receive the best quality water they can for optimal growth.

Read More
Soil-pH feature

January 7, 2018

How Direct-Stick Meters Can Help Take the Guesswork Out…

Monitoring your soil pH is critical to maintaining the health of your greenhouse crops. Try these tips for managing pH, as well as accurately testing your soil with direct-stick soil pH meters.

Read More
Greenspire-Procidic

December 25, 2017

New Fungicide Helps Control Mildews and Rot in Ornament…

Greenspire Global, Inc. has developed Procidic, a bactericide and fungicide that provides effective disease control without synthetics.

Read More

December 21, 2017

Dümmen Orange Confirms Presence of Xanthomonas in Begon…

In a December 16 letter to its customers, Dümmen Orange said it had encountered an issue in its El Salvador-based Las Mercedes production facility, where bacterial leaf spot had been confirmed in begonia production.

Read More

December 21, 2017

Plantpeddler Provides Guidelines for Xanthomonas Bacter…

A leading producer of Begonia young plant liners and finished plants, Cresco, IA-based Plantpeddler has issued the following informational guidelines on Bacterial Leaf Spot in Begonias.

Read More
BASF Orkestra Intrinsic

December 18, 2017

California Growers Have a New Disease Control Tool

BASF’s Orkestra Intrinsic fungicide has been approved in California for control of several ornamental plant diseases.

Read More
Powdery mildew on rosemary. Photo credit: SHS Griffin

December 14, 2017

New Biofungicide Approved for Disease Control in Orname…

Certis USA recently introduced Carb-O-Nator, a new broad-spectrum foliar fungicide that works on contact to control powdery mildew, Alternaria, Anthracnose, Botrytis, Septoria leaf spot, and other diseases.

Read More
cuttings-facility

December 13, 2017

New Webinars Address Effective Propagation Techniques

e-Gro, an online clearing house for alerts about greenhouse disease, insect, environmental, physiological, and nutritional disorders, recently posted two new propagation-related webinars on YouTube.

Read More
Oasis-Transportation-Solutions

December 12, 2017

New Products Designed to Protect the Quality of Plants …

The innovative technologies from Oasis Grower Solutions are aimed at ensuring that the supply chain delivers the best possible consumer plant experience.

Read More
Peat vacuum harvester

December 8, 2017

The Sustainability of the Peat Industry Looks Better T…

Despite talk about alternative products and differences of opinion over its sustainability as a resource, peat is here to stay.

Read More
mycoapply-from-mycorrhizal-applications-feature

December 6, 2017

How Mycorrhizae Provide Value at Your Greenhouse or Nur…

Mycorrhizae create a connection between the roots of a plant and the surrounding growing media. This ultimately leads to better crop health through enhanced nutrient and water uptake.

Read More

December 4, 2017

Raker-Roberta’s Young Plants Debuts as Roberta’s Finali…

On December 1, Eric Wallien of Roberta’s Inc. in Waldron, IN, officially purchased C. Raker & Sons in Litchfield, MI. The new identity of the company is now Raker-Roberta’s Young Plants, according to a Dec. 1 letter to Raker’s customers, suppliers, and business partners from Vice President Susie Raker-Zimmerman. “There have been minimal changes in management and we will be providing the same products and services on which we have built our reputation in the industry,” Raker-Zimmerman said in the letter, which also announced the name change and new logo. The sale of C. Raker & Sons was announced in September . A series of events affecting Raker’s financial situation caused the need for the operation to find an alternate solution. Roberta’s had been a customer of Raker’s since 2011, and the fourth generation, family owned grower-retailer was a fan of Raker’s commitment to quality. The agreement to purchase C. […]

Read More
Remote Sensing Feature

November 28, 2017

Take a Survey About Remote Sensing in the Green Industr…

A team of researchers is planning to submit a proposal to conduct research on the use of remote sensing in indoor and outdoor crops to assess plant traits. But before they submit the proposal, they need your help.

Read More