Winter To-Do List

Winter drafts. They’re enough to send chills down your back, especially when you start thinking about possible gaps, tears and holes in and around your greenhouse. Nothing’s worse than escaping heat and losing money at the same time.

What follows are action items that will help keep more of your heating dollars safely in your pocket as the temperature dips. Bob Fritchen, sales manager at Modine Manufacturing Company, says it best: “Make sure the first cold blast is not the first time you turn on your system.”

Pre-Spring Cleaning

If you’re not cleaning out the heaters and boilers before the season starts, you’re simply wasting your money. Cleaning costs are usually paid back within the first few weeks of the season. “Anyone who doesn’t bother to do that isn’t concerned with the cost of heat,” Zylstra says.

This means surfaces and burners are clean and unobstructed, the inlet for combustion air is clean and not clogged, and filters are cleaned or replaced.

Tune-ups are also important. “For smaller operations who don’t have a professional maintenance crew, make sure to locate a reputable HVAC equipment contractor,” Fritchen says.

Tune-ups will ensure gas pressure is adequate and correct, says Zylstra. “It can cost you a tremendous amount of money if your gas pressure isn’t correct and your heater is running below rated efficiency or capacity.”

Got The Flue…Gas Condenser?

Contact your greenhouse heating company about flue gas condensers,” Zylstra advises. They can increase fuel efficiency of the boilers and optimize the amount of heat energy you can get out of a boiler.

About 15 to 20 percent of all the energy in gas ends up leaving through the chimney. A flue gas condenser can recapture roughly 15 percent of that energy.

Boost Your Unit’s Efficiency

“If you’re using unit heaters, look at replacing them with hot water heat,” Zylstra says. “That can boost your efficiency by 25 to 40 percent.”

If you keep your unit heaters, retrofit them with combustion air separators. These will take combustion air from outside of the greenhouse. They can reduce energy consumption up to 7 percent. Also, if you have a hot water system, add pipe insulation in any area that is not being heated.

A Must Have

“No matter what kind of greenhouse you have, a curtain system is inexpensive, can pay for itself quite quickly and reduce your energy consumption by about 15 to 25 percent − often times even more,” Zylstra says.

When checking your curtain system, make sure it closes all the way. A curtain system that has a few cracks in it is almost worthless when it comes to saving heat and energy.

Energy Audits

One thing TrueLeaf Technologies specializes in is energy audits. “We can look at the greenhouse layout and get all the details of your facility, and look at what the greenhouses should be using compared to what you are actually using,” Zylstra says.

Efficient greenhouses usually rate between 70 and 80 percent. “We find a lot of places in the 40 to 50 percent range,” he says. An audit provides a fresh set of eyes in and around your greenhouse, and it usually pays for itself within one season.

Thermostat Set Points

For those growers with thermostats, Bob Fritchen suggests using lower set points at night. This can save you a lot of energy.

“If it’s 25 degrees out, and your thermostat is set at 70 degrees inside, setting it to 60 or 65 degrees will lessen the temperature difference between outside and in, therefore significantly reducing your heat loss,” Fritchen says.

Energy Task Force

Before winter strikes, Zylstra recommends assigning an energy task force of employees to go around and look for every gap and opening in the greenhouse. All seals and vents should be checked, along with any tears in the poly-film.

Leave a Reply

More From Plant Culture...
Joey Wiseman-2015

October 3, 2015

4 New Hires And Promotions In Horticulture

Management restructuring and growth expansion have prompted several companies in the horticulture industry to bring on more help and promote qualified employees to new positions over the few several months. Here are four that have occurred during the months of July 2015 through September 2015.

Read More
BallSeed New Website September 2015

October 3, 2015 Goes Mobile-Friendly is now mobile-optimized. A new update features responsive design, quick access to WebTrack, an enhanced product search and more. Mobile-Friendly content and clear navigation make information more accessible to customers on-the-move and in the greenhouse.

Read More

October 2, 2015

N.G. Heimos And Dan Schantz Poinsettia Trials Planned For November

Two poinsettia trial open houses are planned for November that showcase hundreds of varieties from top poinsettia breeders. Dan Schantz Farm & Greenhouses will hold an open house on November 12, and N.G. Heimos Greenhouses will hold its open house on November 19.

Read More
Latest Stories

September 20, 2015

Technology Improves Orchid Production At Green Circle G…

Green Circle Growers in Oberlin, Ohio, has a commitment to using production practices that are efficient and sustainable. The operation has been growing Orchids for nine years, and is entering its second full year with its current system, which entails three camera grades. “The camera grading — first at production into a 5-inch pot, then 12 weeks later and a final grade after the stem and buds have developed — is raising our overall quality,” says Wesley Van Wingerden, director of growing for Green Circle Growers. Greenhouse Grower visited the operation to take a tour of its facilities and learn more about its Orchid production. Read on for more details about the process. The first of the camera grades is incorporated into the transplant process, which involves placing the Orchids from a community tray into 5-inch pots. The plants are separated into three sizes with the smallest returning to the […]

Read More

September 15, 2015

Young Plant Growers Weigh In On Crop Gains, Sales Trend…

Almost 100 young plant producers participated in Greenhouse Grower’s 2015 Young Plant Grower Survey, which asked growers questions abot crop categories, sales, order fulfillment and more.

Read More
Top20YPGrowers feature image

September 15, 2015

The State Of The 2015 Young Plant Market

Young plant growers in North America are changing their strategies to stay competitive in today’s market. Here is how 2015 shapes up in trends and statistics.

Read More
Vivero International_Endisch

September 8, 2015

Vivero Internacional Continues To Expand Unrooted Cutti…

The tenth largest cuttings farm in the world, Vivero Internacional was founded in 1991 and began exporting unrooted cuttings in 1993. Based in Tepoztlan, Morelos, just outside of Mexico City, Mexico, the operation opened with 2 hectares or 5 acres. With time and new customers, the farm has experienced rapid growth, now spanning 40 hectares or 99 acres, says Vivero’s Dennis Hitzigrath. “The first 10 years, production was doubling every season,” Hitzigrath says. “In the last three years, it’s been about 20 percent.”     The independent operation grows 100 million cuttings annually for several breeders, serving the North American market. Hitzigrath says consolidation among breeders has brought more of a focus on Vivero Internacional from third-party breeders in recent years. This growing interest is spurring even more growth. “We are planning for a minimum growth of 20 percent,” Hitzigrath says. “We are adding more production space and hope to be […]

Read More

August 19, 2015

Greenhouse Growing Recommendations For Lobularia

Modern-day Lobularias are garden classics with good vigor and long bloom times. These growing recommendations will help keep your crop in prime condition.

Read More
Mike McGroarty, owner of Mike’s Backyard Nursery

July 29, 2015

Backyard Success: Mike McGroarty Educates Aspiring Grow…

Mike’s Backyard Nursery sits on a long, narrow, 5-acre property located in Perry, Ohio. There, customers can find a variety of flowering shrubs available, all in 2-quart pots, and all for sale for $5.97 each. Owner Mike McGroarty, a lifelong resident of Perry, says the town has a lot of plant nurseries, including 100 wholesale growers within a 10-mile radius of his house. That doesn’t discourage McGroarty, because he knows that while there are a lot of nurseries in his area, no one else is doing what he is doing. McGroarty has learned about plants — and marketing them to his audience — through decades of experience. He has never hesitated to pass along his knowledge to other growers looking to start their own backyard operations, and has created an entire program to educate aspiring growers. McGroarty Likes To Practice What He Preaches McGroarty’s operation serves as the laboratory for […]

Read More
cannabis, marijuana plant

June 27, 2015

Concern Grows Over Unregulated Pesticide Use On Cannabi…

As most growers know well, the federal government regulates all insecticides, fungicides, herbicides and other commercial chemicals used on agricultural crops. Therein lies the problem with use of chemicals on cannabis crops – so far, the feds want nothing to do with legalized marijuana. According to “Concern Grows Over Unregulated Pesticide Use On Cannabis,” a June 17 article on the National Public Radio (NPR) network by Agribusiness Reporter Luke Runyon, the lack of regulated chemicals for cannabis has left growers to experiment on their own. “In the absence of any direction the subject of pesticide use on the crop has just devolved to whatever people think is working or they think is appropriate,” said Colorado State University Entomologist Whitney Cranshaw in the NPR report. “Sometimes they’ve used some things that are appropriate, sometimes unsafe.” Denver officials held tens of thousands of marijuana plants earlier this year due to safety concerns, but […]

Read More

June 16, 2015

The Butterfly Effect: Insect’s Wings Key To Azalea Poll…

A researcher from North Carolina State University (NC State) has found that in the case of the flame azalea (Rhododendron calendulaceum), all pollinators are not created equal. In fact, due to the flower’s unique reproductive structure, butterflies — and specifically, their wings — are the key to pollination. The flame azalea is commonly found in the Appalachian Mountains, ranging from as far north as New York to Georgia in the south. Like most azaleas, the flowers are large, and have an unusual structure: both the anther (male) and stigma (female) parts are very elongated and separated from one another. NC State biologist Mary Jane Epps was interested in how the azalea’s flower structure affected its pollination. “In order for a plant to reproduce, a pollinator — usually an insect — has to spread the pollen from the anther to the stigma,” Epps says. “In the case of the flame azalea, […]

Read More
Bee on a Sedum

March 17, 2015

4 Key Pollinator Research Projects To Be Funded By Hort…

The Horticultural Research Institute will grant $125,000 in financial support for four key projects as part of the Horticultural Industry Bee & Pollinator Stewardship Initiative. The Initiative has three primary goals. First, to convene a task force to develop a bee and pollinator stewardship program, including creation of best management practices for plant production. Second, to identify and fund research that will help answer key science questions and fill gaps needed to design and refine the stewardship program. Third, to seek to positively position the horticultural community and its customers by collaborating with other compatible groups interested in augmenting pollinator habitat and protection.

Read More

March 11, 2015

Pollinator Initiative Promotes Bee-Friendly Talking Poi…

AmericanHort and the Society of American Florists are working tirelessly with the ornamental industry's Pollinator Stewardship Initiative on a number of new projects.

Read More

February 11, 2015

Infusion Technology Boosts Seed Performance, Study Sugg…

Seven-year-old wheat seed germination can increase by as much as 83 percent, according to a Vital Force Technology Study that looks at the effects of energy infusion technology on plant vitality.

Read More

February 3, 2015

American Floral Endowment Accepting Research Pre-Propos…

If you are pursuing a floriculture research project, now is the time to apply for funding through the American Floral Endowment. Research pre-proposal applications for 2015-2016 funding are due to AFE by June 1, 2015.

Read More

January 27, 2015

Marijuana’s Trajectory And Ascent To Horticultural Cr…

Marijuana growing is poised for change as growers and researchers focus on improving production practices.

Read More

December 9, 2014

Greenhouse Production: Two Years Of Basics & Beyond…

Greenhouse Grower's Basics & Beyond articles cover some of the latest news and research going on in greenhouse production. Here are article links for the last two years.

Read More
GrowIt! App Wins Gold At Design100 2014 US Mobile & App Design Awards

November 24, 2014

GrowIt! App Wins Gold At Design100 2014 US Mobile &…

The social garden app GrowIt! takes the Gold Winner award at the design100 2014 Mobile & App Design Awards.

Read More

November 10, 2014

The Perennial Farm Joins HGTV HOME Plant Collection

The Perennial Farm joins the HGTV HOME Plant Collection growers' network for 2015.

Read More

November 4, 2014

AmericanHort Publishes Revised American Standard For Nu…

AmericanHort announces the revised American Standard for Nursery Stock (ANSI Z60.1) is now available for industry use. The Standard reflects the consensus of the industry regarding how nursery stock — living plants other than annuals — should be specified and sold within the trade.

Read More

September 26, 2014

Master The Art Of Watering

Watering is elemental to healthy plants, but one of the hardest concepts for new employees to master in the greenhouse. Recommend these tips to start them off right.

Read More